View Full Version : How to Dissolve Old Gas Varnish?


V7
06-26-2007, 09:08 PM
Does anyone know how to dissolve the sticky,carmel like varnish that old gas will leave in a gas tank ? Part two of this question is how do you responsibly dispose of ten plus gallons of old gas and/or are there any uses for it?Thanks.
V7 (Steve)

SquashThatFly
06-26-2007, 09:10 PM
... Part two of this question is how do you responsibly dispose of ten plus gallons of old gas and/or are there any uses for it?
V7 (Steve)



do the neighbors have a pool?

Kustomkarma
06-26-2007, 09:20 PM
To answer your first question, I would try calling around to different radiator shops in your area as some of them may do gas tank work as well. I just dropped my tank off to have the old residue "boiled out" over the next couple of weeks. They should be able to fix any small holes while they're at it. As for the old gas, try contacting your city's solid waste department to see if they offer a recycling or disposal program. I just dropped off about 8 gallons or so at my county landfill for them to properly dispose of it as it's definitely not something you want seeping into the ground or water supply.

Goztrider
06-26-2007, 09:24 PM
Does anyone know how to dissolve the sticky,carmel like varnish that old gas will leave in a gas tank ? Part two of this question is how do you responsibly dispose of ten plus gallons of old gas and/or are there any uses for it?Thanks.
V7 (Steve)

Unless it is completely trashed, we always used the old gas to run in lawnmowers and equipment that it doesn't matter in. I know you're not supposed to do that, but I had a mower that lasted more than 15 years running on old crappy gas - if it was too bad, we'd even dilute it a bit.

If that doesn't work, the 4th of July is just around the corner. Stick it in a bucket and toss in a match and enjoy the show.

desertratrodder
06-26-2007, 09:30 PM
A radiator shop can boil out the tank. Not all do it though.

Last time I had 10 gallons or so of really bad gas, I poured it out of the tank and into a 55 gallon drum.

Used it for parts cleaner for a day or so. Two days later it had evaporated..

Flat Ernie
06-26-2007, 10:27 PM
You can try denatured alcohol - it's about the only thing I've found that will attack the gum, but it's slow. I've tried mineral spirits, brake cleaner, carb cleaner, acetone, good gas - only denatured alcohol has any effect on it...

...but if you can find a rad shop to do it reasonably, do it. Trick is, the EPA is all over rad shops & it's getting expensive (at least around here) to have a tank boiled...

slddnmatt
06-26-2007, 10:35 PM
i used about 3 gallons of acetone on my wifes merc it had 30 yr old gas in it, let it sit and did some sloshing with some nails in it and it cleaned up nice. that shit stinks too don t get any on yr hands!!

Bugman
06-26-2007, 11:06 PM
Lacquer thinner works ok. 'Course then you have to dispose of the dirty lacquer thinner too...

overspray
06-27-2007, 07:36 AM
Lacquer thinner (cheap grade) or acetone, which is in lacquer thinner in varying quantities. It works for soaking carbs too, when you don't have carb cleaner.

overspray

Frank
06-27-2007, 08:17 AM
EPA recommends diluting the old gas with new gas and just use it up. I had 5 gallons that I used up by adding 1 gallon of old to every 10 gallons of new gas I had in my tank. Siphon it out though so you don't get all of the gunk from it.

52pickup
06-27-2007, 09:19 AM
after you get the old gas out of it, go buy a couple bottles of pure lye drain cleaner, the ones that say 100% lye on the bottle. Pour a bottle of lye in the tank and fill with water. one 16oz bottle is usually a pretty good mix for a gas tank, you might add another half bottle. Leave it for at least 24 hours, if you go a little longer you might not have to do a second treatment. The lye wont attack the metal like an acid will, but it will dissolve the goo and gunk in the bottom of gas tanks. To dispose, put it out in a shallow container and let it evaporate off.

It works, I've used this method on 6 cars now, a couple had more than 1" of goo at the bottom of the tank. One other suggestion, seal up all the holes in the top of the tank, including the filler, so you can slosh it around, it will help. Also, don't get the lye mix on you, it will burn, maybe not right away, but you'll feel it eventually.

Gman0046
06-27-2007, 10:52 AM
DO NOT use that old gasoline in your lawn mower. I recently used old gas in the mower and it started losing power as the carbuerator got clogged up. Fortunately a can of carb cleaner restored the power to normal.

38Chevy454
06-27-2007, 10:07 PM
I have done the "ration it out over a few tanks" to get ris of old foul gas, as Frank suggested.

atch
06-28-2007, 07:54 AM
weed control; spray it on the weeds, not the ground.

also good on wasp nests.